Business Aircraft Center
  Home > Newsletter > Spring Aircraft Maintenance Checklist, May 2012

Spring Aircraft Maintenance Checklist

Spring Aircraft Maintenance ChecklistYou already know how important it is to maintain your aircraft's mechanical safety standards throughout the year. But springtime, after a long period of cold and inactivity, is a particularly important time to conduct a thorough maintenance checklist. Here is an overview of important things to check and address before you pull your plane out of the hangar for the spring/summer flying season.

  1. Review the aircraft’s maintenance records.

A smart first step to your spring maintenance checklist is to review your aircraft's maintenance history. What repairs and preventative maintenance have been done recently? Are there any repairs that have been put off that should be done? Now is the time to do them, especially any safety repairs per FAA Airworthiness Directives. These are safety repairs that are required by the FAA to legally fly the plane.

  1. Change the oil and check the fuel system.

Even if you changed the oil and filled the gas tank before laying up your plane for the winter, it’s important to do a spring oil change and fuel system check before getting airborne again. Old oil can become acidic and cause corrosion and pitting of components, such as cam lobes and bearings. Rust can then mix with the oil, causing extensive damage to the engine.

Also check the fuel system. Remove the fuel filter, clean and replace. Check for condensation in the fuel tanks, which is common if the tanks were less-than-full and air is in the tanks. Water in the bottom of the tank can cause corrosion. If pitot and static vent covers were installed before the winter, remove them now. Check that the fuel cocks are open and master switches are back on. Also check:

    • Condition of the fuel tanks and straps
    • Fuel lines for any damage or leaks
    • Fuel drains for water or foreign matter
    • Fuel valve for any damage or leaks
    • Fuel gauge for damage

While an oil change and fuel system flush may seem a redundant expense now, both can prevent much more expensive repairs later on.

  1. Check the battery and other electrical components.

Check and replace the battery if its age or condition is in question. A good rule of thumb is to remove and inspect the battery every 50 hours of use. Also check the condition of the battery leads and mounting apparatus. Also check other electrical components, including circuits, circuit breakers, wiring at terminals and radio and antenna.

  1. Inspect tire pressure and wear.

Just like on a car, tires have a tendency to lose air pressure over time. Make sure your plane's tires are at their recommended psi. Also visually inspect the tires for tread wear and bald spots. Also inspect the wheel brake assembly for leaks and strut condition.

  1. Test wing flaps, tail fins, propeller and landing gear.

Make sure the propeller assembly, wing flaps, tail fins, landing gear and landing gear doors are all in working order. Check that nothing is loose, damaged or dirty.

  1. Inspect for structural damage.

If your aircraft was hangared inside, chances are low that it sustained any winter damage. But it’s smart to do a pre-flight walkaround anyway. Look for any hairline cracks or structural damage on the fuselage and wings due to wind or even contact with another plane. Check gaskets and seals to make sure they aren't corroded or dried out. Also inspect the air intake and cowling, stall warning vent, pilot tube and static ports for animals — small rodents and birds may have built nests in these and other areas.

  1. Give it a good wash.

Finally, give the aircraft a good outside washing and interior cleaning. Make sure no dirt or foreign substances can interfere with wing flap and tail fin operations. A reminder to wash windows in an up and down motion — don’t swirl in circles as this may scratch the windows.

Contact BAC for Spring Repairs

Come to Business Aircraft Center for your plane’s spring maintenance needs. Business Aircraft Center delivers professional, fast and dependable service to get your airplane up and flying safely. Our line service department is provided onsite by Master Aviation, Inc., the Aerostar Center of the Northeast and is available seven days a week. We also offer the absolute lowest full-service jet fuel prices in the NY Tri-state area. For a list of services, visit BAC’s Aircraft Services page If you have any questions, please call us at (203) 748-7000 or email info@businessaircraftcenter.com. To reach Master Aviation, please call (203) 790-5226 or email masterav@att.net.

back to top

 
 
  Facebook Twitter

Call us today! (203) 748-7000

Our Concierge, Reservations and Customer Service Departments are here to assist you!

Low cost jet fuel, New York Airports
 
New Opportunitie at Business Aircraft Center
 
Upcoming Events

Sign up for our newsletter to stay informed on the latest hangar news and events: click here.

Read our newsletter that includes the latest hangar news: General aviation pilots rise up to help victims of Hurricane Florence. Click here.

 
Make A Reservation Executive Jets, Danbury Municipal Airport
 
Corporate Crew Rewards Private flights, Danbury Municipal Airport, CT
 
 
         
     
  site by falcone creative design   National Business Aviation AssociationAircraft Owners and Pilots Association